Previous Article | Next Article ![]()
Applied and Environmental Microbiology, February 1999, p. 431-437, Vol. 65, No. 2
Biopolymer Research
Unit1 and
Plant Polymer Research
Unit,2 National Center for Agricultural
Utilization Research, Agricultural Research Service, U.S. Department of
Agriculture, Peoria, Illinois 61604, and
Marine Science
Station, University of Puerto Rico, Isla Magueyes, Lajas, Puerto Rico
006673
Received 17 August 1998/Accepted 12 November 1998
Extruded bioplastic was prepared from cornstarch or
poly(
0099-2240/99/$00.00+0
Degradation of
Starch-Poly(
-Hydroxybutyrate-Co-
-Hydroxyvalerate) Bioplastic in
Tropical Coastal Waters
-hydroxybutyrate-co-
-hydroxyvalerate) (PHBV) or blends
of cornstarch and PHBV. The blended formulations contained 30 or 50%
starch in the presence or absence of polyethylene oxide (PEO), which enhances adherence of starch granules to PHBV. Degradation of these
formulations was monitored for 1 year at four stations in coastal water
southwest of Puerto Rico. Two stations were within a mangrove stand.
The other two were offshore; one of these stations was on a
shallow shoulder of a reef, and the other was at a location in
deeper water. Microbial enumeration at the four stations revealed considerable flux in the populations over the course of the year. However, in general, the overall population densities were 1 order of
magnitude less at the deeper-water station than at the other stations.
Starch degraders were 10- to 50-fold more prevalent than PHBV
degraders at all of the stations. Accordingly, degradation of the
bioplastic, as determined by weight loss and deterioration of tensile
properties, correlated with the amount of starch present (100% starch
>50% starch > 30% starch > 100% PHBV). Incorporation of
PEO into blends slightly retarded the rate of degradation. The rate of
loss of starch from the 100% starch samples was about 2%/day, while
the rate of loss of PHBV from the 100% PHBV samples was about
0.1%/day. Biphasic weight loss was observed for the starch-PHBV blends
at all of the stations. A predictive mathematical model for loss of
individual polymers from a 30% starch-70% PHBV formulation was
developed and experimentally validated. The model showed that PHBV
degradation was delayed 50 days until more than 80% of the starch was
consumed and predicted that starch and PHBV in the blend had half-lives
of 19 and 158 days, respectively. Consistent with the relatively low
microbial populations, bioplastic degradation at the deeper-water
station exhibited an initial lag period, after which degradation rates
comparable to the degradation rates at the other stations were
observed. Presumably, significant biodegradation occurred only after
colonization of the plastic, a parameter that was dependent on the
resident microbial populations. Therefore, it can be reasonably
inferred that extended degradation lags would occur in open ocean water
where microbes are sparse.
*
Corresponding author. Mailing address: Biopolymer
Research Unit, National Center for Agricultural Utilization Research,
Agricultural Research Service, U.S. Department of Agriculture, 1815 N. University St., Peoria, IL 61604. Phone: (309) 681-6591. Fax: (309)
681-6689. E-mail: bprvg{at}mail.ncaur.usda.gov.
Copyright © 2009 by the American Society for Microbiology. For an alternate route to Journals.ASM.org, visit: http://intl-journals.asm.org | More Info»