Previous Article | Next Article ![]()
Applied and Environmental Microbiology, March 2002, p. 1440-1445, Vol. 68, No. 3
0099-2240/02/$04.00+0 DOI: 10.1128/AEM.68.3.1440-1445.2002
Copyright © 2002, American Society for Microbiology. All Rights Reserved.
Division of Geological and Planetary Sciences, California Institute of Technology, Pasadena, California 91125,1 Corrosion and Environmental Effects Laboratory, Department of Materials Science and Engineering, University of Southern California, Los Angeles, California 90089-02412
Received 11 September 2001/ Accepted 12 December 2001
| ABSTRACT |
|---|
|
|
|---|
| INTRODUCTION |
|---|
|
|
|---|
A prevailing theory of MC holds that biofilms promote corrosion by inducing the formation of corrosion cells. This is thought to occur as a consequence of aerobic respiratory activity within biofilms that leads to the establishment of local cathodic and anodic regions on the steel surface, which promotes electron flow (6). Recent evidence, however, suggests that aerobically respiring bacteria may protect steel from corrosion over the long term (5), which raises questions regarding the extent to which aerobic respiration contributes to MC. Other explanations for MC include corrosion promotion by anaerobes such as sulfate-reducing and iron-reducing bacteria. Current theories maintain that sulfate reducers promote corrosion by consuming hydrogen and inducing ferrous sulfide formation and that iron reducers promote corrosion by reductively dissolving the protective ferric oxide coating that forms on the steel surface (6, 17). Biofilm communities that develop on the surfaces of corroding materials in natural environments are heterogeneous, and therefore there is significant uncertainty concerning how these communities affect corrosion in any given environment.
Our goal was to take a reductionist approach to study the complex problem of MC. Specifically, we sought to create a single-species biofilm system to determine under what conditions and by which mechanisms actively respiring bacteria influence the corrosion of steel. We selected Shewanella oneidensis strain MR-1 (13) as the model organism for this study because it is amenable to genetic manipulation and is closely related to bacteria that have been isolated from corroding steel pipelines (20). S. oneidensis is a member of the gamma subdivision of the Proteobacteria and is a facultative anaerobe that can respire by using oxygen or ferric iron as its terminal electron acceptor. Thus, the respiratory versatility of S. oneidensis provided an opportunity to generate specific mutants to test the competing hypotheses about the effects of aerobic respiration and iron respiration on MC and to determine which effect dominates in a biofilm system in which both processes could occur.
Two mutant strains were generated by transposon mutagenesis. Transposon insertions were made by mating S. oneidensis strain MR-1 with Escherichia coli strain B-2155 containing pBSL180, a suicide plasmid carrying a mini-Tn10 transposon derivative marked with a kanamycin cassette. Exconjugants were selected on LML medium (2) supplemented with 50 µg of kanamycin per ml under aerobic conditions. The mutants were inoculated into 96-well microtiter plates filled with Luria-Bertani medium containing kanamycin and allowed to grow overnight. Each microtiter plate was processed to identify mutants defective in biofilm formation (16). Iron reduction mutants were identified as previously described (15).
One representative biofilm mutant and one representative iron reduction mutant were selected for further study (Fig. 1A). The biofilm mutant contained an insertion in the fliI gene that encodes a protein necessary for the synthesis of flagella. The S. oneidensis FliI homolog exhibits 68% identity and 82% similarity to the FliI protein of Vibrio parahaemolyticus, as determined by a pairwise amino acid alignment performed with the National Center for Biotechnology Information program BLAST2. Flagellar motility has been shown to be critical for the initial stages of biofilm formation in other gamma proteobacteria (18). The iron respiration mutant contained an insertion in the menC gene that encodes an enzyme necessary for the synthesis of menaquinone, a lipophilic electron carrier in the respiratory chain that conveys electrons to low-potential electron acceptors like iron; menaquinone is not necessary for electron transport to oxygen, and thus the menC mutant behaves normally with respect to aerobic respiration (11, 15).
|
The abilities of the mutants to reduce both soluble and solid forms of ferric iron [Fe(III)] were also determined. Anaerobic LML medium supplemented with 20 mM ferric citrate [for soluble Fe(III) reduction assays] or with 20 mM goethite [for solid Fe(III) reduction assays] was inoculated with the appropriate Shewanella strain by using standard anaerobic techniques (12). Reduction of Fe(III) to ferrous iron [Fe(II)] was measured by the ferrozine assay (21) with a Beckman DU 640 spectrophotometer at 564 nm. The wild type and the fliI mutant reduced soluble Fe(III) to Fe(II) at the same rate, whereas the menC mutant was completely blocked in this process. When grown on solid Fe(III) (e.g.,
· FeOOH, synthetic goethite), however, the fliI mutant reduced iron at a lower rate than the wild type (Fig. 1C), presumably because direct contact between cells and minerals facilitates (but is not essential for) electron transfer in this organism (14).
Having genetically separated biofilm formation from iron reduction, we were able to determine the effects of microbial attachment and respiration on corrosion. Electrochemical impedance spectroscopy (EIS) was used to determine how the mutants influenced the corrosion potential (Ecorr) and corrosion rate of 1018 steel compared to the effects of the wild type and an uninoculated control. Because EIS is a nondestructive technique, it allows the corrosion rate for a given material to be monitored in a test cell whose solution chemistry can be manipulated and measured over time. Mild steel 1018 coupons (3 by 3 in.; Metal Samples, Inc.) were sterilized, weighed, and placed in the base of a glass corrosion chamber with an exposed area of 20 cm2. Then 75 ml of LML medium was added to the chamber. An autoclavable Ag/AgCl electrode was used as the reference electrode, and stainless steel 316 was used as the counterelectrode. Impedance spectra were recorded with an applied alternating current signal of 20 mV (rms) and a frequency range from 105 to 10 x 10-3 Hz by using Gamry equipment. The EIS data were analyzed by using the BASICS module of the ANALEIS software (10).
For each experiment, we recorded the changes in the impedance spectrum determined at the Ecorr, the concentrations of Fe(III) and Fe(II) in solution, and the planktonic cell numbers daily. The initial impedance measurements were taken after 4 h, and then 1 ml of a fresh overnight culture was added to the chamber. The chamber was heated to 30°C, and the temperature was kept constant for the rest of the experiment. Impedance spectra were recorded every 24 h for five additional days. At the end of the experiment, the steel coupons were rinsed in water, DAPI stained, and observed with a fluorescent light microscope to assess biofilm formation. Biofilm formation on the steel coupons followed the pattern of attachment observed with the steel chips (e.g., the wild type and menC mutant formed normal biofilms, whereas the fliI mutant was less dense). Nevertheless, coverage was not uniform over the surfaces of the coupons for any strain. Such patchiness appears to be the rule for the majority of biofilms that have been examined (4). Subsequently, the chips were washed in 0.5 M HCl containing 3.5 g of hexamethylene tetramine per ml for 10 min and weighed to determine differences in mass loss. The EIS data were displayed as Bode plots in which the logarithm of the impedance modulus (|Z|) was plotted versus the logarithm of the frequency (f) of the applied alternating current signal. When the frequency of an applied signal is low (f
0), the impedance measurements reflect the polarization resistance (Rp), which is inversely proportional to the corrosion rate (8).
Figure 2 shows representative Bode plots obtained for 1018 steel in parallel experiments for chambers containing the wild type, the fliI mutant, the menC mutant, and an uninoculated control. Initial impedance spectra were recorded 4 h after inoculation with bacteria and were the same for all test cells. After 5 days of static incubation, significant differences in the low-frequency part of the impedance spectra were observed. The general shape of the impedance spectra, which in this case corresponds to a parallel combination of the electrode capacitance and Rp (9), did not differ in the presence of the different strains. This indicates that although the corrosion rates changed, the corrosion mechanism remained the same. Compared to the uninoculated control, the wild type and the fliI mutant maintained Rp at a high level (although the Rp maintained by the fliI mutant was lower than the Rp maintained by the wild type). The menC mutant maintained Rp at a lower level than both the wild type and the fliI mutant but still provided better corrosion protection than the uninoculated control. The planktonic cell concentrations were approximately the same for all cultures, on the order of 107 cells/ml. In these experiments, mass loss from the steel coupons was greatest for the uninoculated control (corresponding to a corrosion rate of 0.4 mg · cm-2 · day-1), a factor of 2 less for the menC and fliI mutants, and a factor of 4 less for the wild type.
|
|
These results suggested that the concentration of Fe(II) in solution was a critical variable in corrosion inhibition. To test this hypothesis, we performed week-long EIS experiments with Vibrio cholerae strain El Tor N16961 [another gamma proteobacterium that is similar to S. oneidensis but cannot respire Fe(III)] and a different iron reduction mutant of S. oneidensis identified in our screening analysis (this mutant contained a transposon insertion in a gene that was 100% identical, as determined by a pairwise alignment using BLAST, to the S. oneidensis strain MR-1 mtrB gene [2]). These experiments were performed by using the procedures described above for the experiments performed with the wild-type, fliI, and menC strains. As predicted, the Ecorr, corrosion rate, and concentration of Fe(II) in the medium for these strains were about the same as those measured for the menC mutant (data not shown). Because all of the strains could form normal biofilms and still decreased corrosionalbeit not as effectively as strains that could also respire Fe(III)these data argue against the notion that biofilm-induced corrosion cells promote corrosion.
Further support for the hypothesis that Fe(II) has a protective role came from a dilution-killing experiment performed with the wild type. In this experiment we compared the changes in the Ecorr, the corrosion rate, and the concentration of ferrous iron in solution generated by the wild type over a 2-week period, subject to manipulation of the medium. As in the experiment described above, the Ecorr remained high after 5 days of static incubation compared to the value obtained with the uninoculated control, yet once fresh medium was pumped into the chamber (day 5), the Ecorr decreased to more negative values and decreased even further once the cells were killed by the addition of kanamycin (50 µg/ml) (day 9). As predicted, the corrosion rate remained low in the presence of active Fe(III)-respiring bacteria [even after dilution, as some Fe(II) remained in the system] but rose significantly after the addition of kanamycin. Although the concentration of planktonic cells remained the same (roughly 107 cells/ml) until the time of killing, the Fe(II) concentration rose and fell parallel to the changes in the Ecorr. The pH remained circumneutral throughout the experiment.
We can interpret our data by using a theoretical representation of anodic and cathodic polarization curves. In Fig. 4A the potential is plotted versus the logarithm of the current density. Current density is proportional to the reaction rate. It is assumed that the anodic iron oxidation reaction is a charge transfer-controlled reaction resulting in a straight line, while for the cathodic oxygen reduction reaction it is assumed that the charge transfer-controlled reaction at a low current density is followed by the limiting current density for oxygen reduction (iL) that depends on the oxygen concentration in the bulk solution. The corrosion reaction for iron in aerated, neutral media is diffusion controlled; i.e., the corrosion current density (icorr) equals the limiting current density (iL). Since aerobic respiration consumes oxygen, iL decreases, resulting in a decrease in Ecorr (as observed for the menC mutant, which forms a normal biofilm and respires aerobically). Fe(III) respiration by bacteria increases the concentration of Fe(II) in solution, shifting the reversible potential for the Fe(0)/Fe(II) couple to more positive values (E'o) than those under the initial conditions (Eo).
|
Independent experiments to evaluate the effects of wild-type S. oneidensis strain MR-1 on the corrosion of mild steel, brass, and aluminum alloy 2024 (13a) confirmed that iron reduction plays a central role in this model of corrosion protection. In these experiments Ecorr increased and icorr decreased, results that are similar to the results obtained in the present study with mild steel, yet when S. oneidensis was placed in contact with brass or aluminum, Ecorr and icorr both decreased due to aerobic respiration. The shift of the anodic polarization curve observed for the Fe(0)-Fe(II) reaction (and hence an increase in Ecorr) did not occur in these cases as biologically catalyzed redox chemistry could not occur with these materials. Furthermore, in the case of 1018 steel, when the growth medium was changed to include phosphate, Fe3(PO4)2 · 8H2O (vivianite) formed instead of goethite, and no difference in corrosion protection was observed between the menC mutant and the wild type (Dubiel and Newman, unpublished data). This was expected because the ferrous iron in vivianite cannot be used as a terminal electron acceptor by S. oneidensis.
In conclusion, our results suggest that both aerobic respiration and anaerobic respiration can significantly contribute to corrosion protection in systems in which water is quiescent. Depending on the chemistry of the water in which Fe(0) oxidation occurs, in the presence of iron-reducing bacteria the resulting corrosion product(s) may play a protective role beyond merely preventing attack by oxygen by forming a physical barrier at the surface. If the corrosion product contains Fe(III), iron reducers may utilize this substrate as a terminal electron acceptor for anaerobic respiration, and the resulting Fe(II) may scavenge oxygen in the water column. Although biofilms in environments in which corrosion is a problem are not limited to single species, such as S. oneidensis, our results point to a general principle: biofilms may be beneficial in the context of corrosion. Indeed, the physiology of the bacteria that comprise a biofilm and the flow rate and chemistry of the water which they inhabit to a large extent determine the ultimate impact of the microorganisms on corrosion.
| ACKNOWLEDGMENTS |
|---|
Support was provided by a grant from the Office of Naval Research to D.K.N.
| FOOTNOTES |
|---|
| REFERENCES |
|---|
|
|
|---|
This article has been cited by other articles:
| |||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||
| J. Bacteriol. | Microbiol. Mol. Biol. Rev. | Eukaryot. Cell | All ASM Journals |
|---|